by SK | 15 November, 2017 | Industrial and commercial descaler
SupermarketSavings Brochure Vulcan – the alternative to water softeners. Vulcan is the eco-friendly water treatment system that protects piping systems and production equipment against scale and rust deposits. Special electronic impulses change the crystallization process of the liquid calcium, removing its adhesive properties. This results in an effective scale-free solution for your supermarket operation. Supermarket misters The fine spray nozzles and filters of mister systems suffer extremely from scale build-up. With the Vulcan treatment misters in food sections clog up less, filters last much longer and pressure increases resulting in finer mist production. The misters will also require less frequent drainage and flushing. Machinery and equipment perform more reliably: cooling towers heating systems etc. Less time and effort n maintenance in building and facilities Faster cleaning of kitchens and bathrooms Filters, shower heads and sinks stay cleaner Considerable savings on cleaning agents Cleaner sprinkler nozzles for misters Prolonging the life of water based production equipment Descaling the whole water system Saving time on maintenance and cleaning Increasing the efficiency of hot water systems Removing the need for descaling chemicals and salts Preventing new scale deposits from forming...
by SK | 15 November, 2017 | Uncategorized
Cooling Towers StudyBrochure Vulcan – The chemical-free solution. Scale deposits reduce the effectiveness and increase the operating costs of cooling towers. Using expensive chemicals such as chlorine, phosphates and acids is the traditional way to eliminate the scale problem. The Vulcan water treatment system is the eco-friendly and chemical-free alternative. Open circuit cooling towers Vulcan should be installed just before the heat exchanger. Installation is simple and no pipe cutting is needed. Please ensure to regularly drain the circuit at the bottom of the basin or use a centrifugal filter to take away remaining solids from the cooling tower water. Case study “After installing the Vulcan unit, we were able to stop all chemical based cooling tower treatment. After approximately six months, almost no scale build up was observed. Small amounts of scale that were found on the cooling tower are easily removed with the wipe of a finger. With these results, we can confirm the effectiveness of the Vulcan” Removal of scale deposits Maximised tower cycles Water consumption and wastage will be reduced Dramatic reduction of chemical usage Bacteria and biofilm will be reduced Maintenance, repairs and replacements will be reduced Machinery and equipment perform more reliably: cooling towers, heating systems, etc. Reduces and prevents scale deposits throughout the entire piping system Less time and effort on maintenance in building and facilities Faster cleaning of kitchens and bathrooms Filters, shower heads and basins stay cleaner Considerable savings on cleaning agents Cleaner sprinkler nozzles for garden irrigation Food and beverages keep their natural taste Reduction of existing scale in the piping system Installation without cutting the pipe From 1⁄2″...
by SK | 15 November, 2017 | Uncategorized
Solar Heating Brochure Vulcan – The alternative to water softeners Using solar powered water heaters are a smart green alternative to traditional heating methods. They utilize sustainable resources, help the environment and save money. In order to ensure the effective performance of these eco-friendly heating systems, engineers recommend the use of an anti-scale product. Improved water quality Hard water naturally forms scale when there is an increase in temperature or change of pressure. This leaves deposits on the tubes, the heat exchangers, the collectors or tanks. The scale prevents heat from transferring efficiently, therefore the working capacity of your machinery is minimized, increasing your back-up energy bill. Vulcan reduces scaling and effectively dissolves existing deposits in solar water heating systems. Cleaner heat exchangers and distributor pipes Reduces scale build-up in collectors Protects hot water tanks and vacuum tubes Protects the system from over-heating No need to circulate acids pH levels remain unchanged, preventing corrosion Reduces malfunctioning of valves in primary circuits Fewer maintenance visits required for your equipment...
by SK | 15 November, 2017 | Uncategorized
Snow Production Ice Rinks Brochure The Vulcan eco-friendly water treatment system works without salt or chemicals. improves the water quality and maximizes your snow production for better snow that lasts longer. The quality and quantity of snow in snow production is largely affected by the water quality. The Vulcan Electronic – Impulse – Technology changes the typical crystal structure of scale – from a chaotic clutter into a well aligned mono-crystal. The water droplets are finer, which allows you to produce more snow with a better snow crystal structure that will last longer. Better water characteristics for snowmaking Vulcan prevents scaling in water heaters, pipes and ice resurfacers (e.g. Zamboni or Olympia) Faster Quasi Liquid Layer setup time Finer ice crystals with a decrease of diameter (-20%) and a decrease of volume (-45%) Water surface tension decreases by 15 – 20% Vulcan produces mono-crystal nucleuses in the water that form organized, more stable ice and snow crystals Soft-water-characteristics result in finer mist and pulverization with finer droplets Vulcan prevents scale buildup in the pipe and the nozzles Improvement of your snow production Improvement of snow structure, water content, density, snow temperature and grain size Vulcan prevents scaling up of the cannon‘s spray nozzles Maximized production output with less water loss Finer snow crystals with a decrease of diameter (-20%) and a decrease of volume (-45%) The finer water droplets freeze earlier Snow is dryer as it contains less unfrozen water Smaller and dryer crystals have a lower temperature of approx. -2.5°C/...
by SK | 15 November, 2017 | Uncategorized
Pools & Spa Cooling Tower Solar Savings Brochure Vulcan – The alternative to water softeners Swimming pools and spas are complex systems that demand rigorous cleaning efforts and complicated water treatment procedures. Their pumping and ltration systems are very sensitive to scaling. Cleaning these consumes tremendous amounts of time and money on a daily basis. Vulcan reduces the cleaning for pools and spas, the water line, tiles, grids, oors and pool walls. The eco-friendly solution Vulcan significantly reduces scaling in and around the swimming pool, in the whole piping system and in the lters and pumps. Vulcan treats water with special electronic impulses that affect the adhesive properties of scale. This is 100% eco-friendly and works without any chemicals or salt. Scale is simply washed away with the water as a fine powder. Benefits for your pools and spas Reduction of scale deposits in the whole pool and spa system Longer life and improved performance of filters and pumps Reduction of chemicals that control bacteria and the pH-levels Extensive reduction of cleaning efforts Heat exchangers operate more efficiently Vulcan reduces the cleaning effort for the pool itself, the water line, tiles, grids, floors and walls Heat exchangers operate more efficiently Reduction in bio-film Longer life and improved performance of filters and pumps eduction of cleaning agents and chemicals by up to 50% Chlorine can be reduced by 10% to 25% Active oxygen can be cut back step by step starting with a reduction of 10% The use of pH adjustors can be reduced in the same ratio to which the disinfectant has been reduced Improved water quality Pools are...
